氣缸的技術參數
1)氣缸的輸出力 氣缸理論輸出力的設計計算與液壓缸類似,可參見液壓缸的設計計 算.如雙作用單活塞桿氣缸推力計算如下: 理論推力(活塞桿伸出) Ft1=A1p (13-1) 理論拉力(活塞桿縮回) Ft2=A2p 式中 (13-2) Ft1,Ft2——氣缸理論輸出力(N) ; A1,A2——無桿腔,有桿腔活塞面積(m2) ; p — 氣缸工作壓力(Pa) . 實際中, 由于活塞等運動部件的慣性力以及密封等部分的摩擦力, 活塞桿的實際輸出力 小于理論推力,稱這個推力為氣缸的實際輸出力.
氣缸的效率 η 是氣缸的實際推力和理論推力的比值,即 F η= Ft (13-3) 所以 F = η ( A1 p ) 氣缸的效率取決于密封的種類,氣缸內表面和活塞桿加工的狀態及潤滑狀態.此外,氣 缸的運動速度,排氣腔壓力,外載荷狀況及管道狀態等都會對效率產生一定的影響.
2) 負載率β 從對氣缸運行特性的研究可知, 要精確確定氣缸的實際輸出力是困難的. 于是在研究氣缸性能和確定氣缸的出力時,常用到負載率的概念.氣缸的負載率β定義為 β= 氣缸的實際負載 F × 100 % 氣缸的理論輸出力 Ft (l3-5) 氣缸的實際負載是由實際工況所決定的,若確定了氣缸負載率 θ,則由定義就能確定氣 缸的理論輸出力,從而可以計算氣缸的缸徑. 對于阻性負載,如氣缸用作氣動夾具,負載不產生慣性力,一般選取負載率β為 0.8; 對于慣性負載,如氣缸用來推送工件,負載將產生慣性力,負載率β的取值如下 β<0.65 當氣缸低速運動,v <100 mm/s 時; β<0.5 當氣缸中速運動,v=100～500 mm/s 時; β<0.35 當氣缸高速運動,v >500 mm/s 時.
3)氣缸耗氣量 氣缸的耗氣量是活塞每分鐘移動的容積,稱這個容積為壓縮空氣耗氣 量,一般情況下,氣缸的耗氣量是指自由空氣耗氣量. 4)氣缸的特性 氣缸的特性分為靜態特性和動態特性.氣缸的靜態特性是指與缸的輸 出力及耗氣量密切相關的zui低工作壓力,zui高工作壓力,摩擦阻力等參數.氣缸的動態特性 是指在氣缸運動過程中氣缸兩腔內空氣壓力,溫度,活塞速度,位移等參數隨時間的變化情 況.它能真實地反映氣缸的工作性能. 四,氣缸的選型及計算 1.氣缸的選型步驟 氣缸的選型應根據工作要求和條件, 正確選擇氣缸的類型. 下面以單活塞桿雙作用缸為 例介紹氣缸的選型步驟. (1)氣缸缸徑.根據氣缸負載力的大小來確定氣缸的輸出力,由此計算出氣缸的缸徑. (2)氣缸的行程.氣缸的行程與使用的場合和機構的行程有關,但一般不選用滿行程. (3)氣缸的強度和穩定性計算 (4)氣缸的安裝形式.氣缸的安裝形式根據安裝位置和使用目的等因素決定.一般情況 下,采用固定式氣缸.在需要隨工作機構連續回轉時(如車床,磨床等) ,應選用回轉氣缸. 在活塞桿除直線運動外,還需作圓弧擺動時,則選用軸銷式氣缸.有特殊要求時,應選用相 應的特種氣缸. (5)氣缸的緩沖裝置.根據活塞的速度決定是否應采用緩沖裝置. (6)磁性開關.當氣動系統采用電氣控制方式時,可選用帶磁性開關的氣缸. (7)其它要求.如氣缸工作在有灰塵等惡劣環境下,需在活塞桿伸出端安裝防塵罩. 要求無污染時需選用無給油或無油潤滑氣缸. 2.氣缸直徑計算 氣缸直徑的設計計算需根據其負載大小,運行速度和系統工作壓力來決定.首先,根據 氣缸安裝及驅動負載的實際工況,分析計算出氣缸軸向?qū)嶋H負載 F,再由氣缸平均運行速度 來選定氣缸的負載率 θ,初步選定氣缸工作壓力(一般為 0.4 MPa～0.6 MPa) ,再由 F/θ, 計算出氣缸理論出力 Ft, zui后計算出缸徑及桿徑, 并按標準圓整得到實際所需的缸徑和桿徑. 例題 氣缸推動工件在水平導軌上運動.已知工件等運動件質量為 m=250 kg,工件與 導軌間的摩擦系數 =0.25,氣缸行程 s 為 400 mm,經 1.5 s 時間工件運動到位,系統 工作壓力 p = 0.4 MPa,試選定氣缸直徑. 解:氣缸實際軸向負載 F = mg =0.25 × 250 × 9.81=613.13 N 氣缸平均速度 s 400 v= = ≈ 267 mm/s t 1.5 選定負載率 θ =0.5 則氣缸理論輸出力 F1 = F 雙作用氣缸理論推力 θ = 613.13 = 1226.6 N 0.5 1 F1 = πD 2 p 4 氣缸直徑 按標準選定氣缸缸徑為 63 mm. D= 4 Ft 4 ×1226.3 = ≈ 62.48 mm πp 3.14 × 0.4

SMC氣缸型號：
CHDKGB50-10
CHDKGB50-100
CHDKGB50-15
CHDKGB50-15M
CHDKGB50-20
CHDKGB50-25
CHDKGB50-35
CHDKGB50-40
CHDKGB50-50
CHDKGB50-75
CHDKGB5050MXC62
CHDKGB63-100
CHDKGB63-25
CHDKGB63-30
CHDKGB63-35
CHDKGB63-35M
CHDKGB63-40
CHDKGB63-50
CHDKGB63-75
CHDKGB63-80M
CHDKGB80-100
CHDKGB80-100M
CHDKGB80-15M
CHDKGB80-150
CHDKGB80-25
CHDKGB80-50
CHDKGB80-75
CKZ3T50-90T
CKZT50-A015CB
CKZ3T63-105T
CKZT63-A045CS
CKZ1N50-135LT
CKZ1N50-135RT
CKZ2N50-120RT
CKZ2N50-135RT
CKZ3N50-45DT
CKZ3N50-90DP
CKZ3N63-45DP
CKZ3N63-90DT
CKZ-50A011
CKZN50-135LN
CKZN50-135RN
CKZT40-135T
CKZT40-30T
CKZT40-45T
CKZT40-60T
CKZT40-A015CS
CKZT40-A015LS
CKZT40-A015RS
CKZT40-A045CS
CKZT63-120T
CKZT63-A045CS
CKZT63-A045LS
CKZT63-A045RS
CKZT63TN-120T
CKA80-KRF0027-75Y-P5DWZ
CKA-K75
CKA-Y04
CKA-YA04
CKB40-17-102B
CKB40-18-207A
CKB40-18-207B
CKB-Y04
CKCV32-135B-RH
CKG1A40-100
CKG1A40-100Y
CKG1A40-100YA
CKG1A40-125
CKG1A40-125Y
CKG1A40-125YA
CKG1A40-50
CKG1A40-50Y
CKG1A40-50YA
CKG1A40-50YA-P
CKG1A40-50Y-P
CKG1A40-50YZ
CKG1A40-75Y
CKG1A40-75YA
CKG1A40-75YA-P
CKG1A40-75Y-P
CKG1A40-75Y-P5DWL
CKG1A40-75YZ
CKG1A50-100
CKG1A50-100Y
CKG1A50-100YA
CKG1A50-100YABD-L
CKG1A50-100YA-P
CKG1A50-100YBD-L
CKG1A50-100Y-P
CKG1A50-125-X276A
CKG1A50-125Y
CKG1A50-125YA
CKG1A50-125YABD-L
CKG1A50-125YAD
CKG1A50-125YA-P
CKG1A50-125YBD-L
CKG1A50-125YD
CKG1A50-125Y-P
CKG1A50-150
CKG1A50-150Y
CKG1A50-150YA
CKG1A50-150YABD-L
CKG1A50-150YBD-L
CKG1A50-40YA
CKG1A50-50
CKG1A50-50Y
CKG1A50-50YA
CKG1A50-50YA-X276A
CKG1A50-50YA-X276B
CKG1A50-50YABDL
CKG1A50-50YA-P
CKG1A50-50YBDL
CKG1A50-50Y-P
CKG1A50-50Y-X276A
CKG1A50-50Y-X276B
CKG1A50-75
CKG1A50-75Y
CKG1A50-75YA
CKG1A50-75YABDL
CKG1A50-75YA-P
CKG1A50-75YA-X738
CKG1A50-75YBDL
CKG1A50-75Y-P
CKG1A50-75Y-X1515
CKG1A50-75Y-X738
CKG1A50-75YZ
CKG1A63-100
CKG1A63-100-P
CKG1A63-100Y
CKG1A63-100YA
CKG1A63-100YABD-L
CKG1A63-100YA-P
CKG1A63-100YBD-L
CKG1A63-100Y-P
CKG1A63-125
CKG1A63-125B
CKG1A63-125Y
CKG1A63-125YA
CKG1A63-125YABD-L
CKG1A63-125YAD
CKG1A63-125YA-P
CKG1A63-125YBD-L
CKG1A63-125YD
CKG1A63-125Y-P
CKG1A63-150Y
CKG1A63-150YA
CKG1A63-150YABD-L
CKG1A63-150YA-L
CKG1A63-150YA-P
CKG1A63-150YBD-L
CKG1A63-150Y-L
CKG1A63-150Y-P
CKG1A63-150Z
CKG1A63-200Y
CKG1A63-200Y-P
CKG1A63-30
CKG1A63-300Y-P
CKG1A63-50
CKG1A63-50Y
CKG1A63-50YA
CKG1A63-50YABDL
CKG1A63-50YA-P
CKG1A63-50YBDL
CKG1A63-50Y-P
CKG1A63-75
CKG1A63-75Y
CKG1A63-75YA
CKG1A63-75YABDL
CKG1A63-75YA-P
CKG1A63-75YBDL
CKG1A63-75Y-P
CKG1A63-75Y-P
CKG1A63-KRF0028-125YBDL
CKG1A63-KRF0028-75YBD
CKG1B40-50
CKG1B40-50Y
CKG1B40-50YA
CKG1B50-100
CKG1B50-100I
CKG1B50-100Y
CKG1B50-100YA
CKG1B50-100YA-X276A
CKG1B50-100YAL
CKG1B50-100YL
CKG1B50-100Y-X276A
CKG1B50-125Y
CKG1B50-125YA
CKG1B50-125YAL
CKG1B50-125YL
CKG1B50-150
CKG1B50-150Y
CKG1B50-150YA
CKG1B50-25Y
CKG1B50-25YA
CKG1B50-50
CKG1B50-50-P
CKG1B50-50-X1515
CKG1B50-50Y
CKG1B50-50YA
CKG1B50-75Y
CKG1B50-75YA
CKG1B50-75YA-X276A
CKG1B50-75YAL
CKG1B50-75YL
CKG1B50-75Y-X276A
CKG1B63-100
CKG1B63-100Y
CKG1B63-100YA
CKG1B63-100YA-P
CKG1B63-100YZ
CKG1B63-125
CKG1B63-125I
CKG1B63-125Y
CKG1B63-125YA
CKG1B63-150Y
CKG1B63-150YA
CKG1B63-50
CKG1B63-50Y
CKG1B63-50YA
CKG1B63-50Z
CKG1B63-75
CKG1B63-75Y
CKG1B63-75YA
CKG1P63-150YA-P
CKG1P63-150Y-P
CKG40-R050
CKG40-R075
CKG40-R100
CKGA100-125Y
CKGA100-150YL
CKGA100-150Y-P
CKGA32-100Y-X1046
CKGA32-125Y-X1046
CKGA32-75Y-X1046
CKGA32-B6859-100Y
CKGA32-B6859-125Y
CKGA32-B6859-150Y
CKGA32-B6859-50Y
CKGA32-B6859-75Y
CKGA80-100Y
CKGA80-125Y
CKGA80-150YL
CKGA80-50Y
CKP1A63-100Y
CKP1A63-100YA
CKP1A63-125
CKP1A63-125Y
CKP1A63-125YA
CKP1A63-125YA-P74
CKP1A63-125Y-P74
CKP1A63-150
CKP1A63-150Y-P74-85G-X906
CKP1A63-150Y
CKP1A63-150YA
CKP1A63-200Y
CKP1A63-200YA
CKP1A63-50Y-P74-85G-X1442
CKP1A63-50Y
CKP1A63-50YA
CKP1A63-75Y
CKP1A63-75YA
CKP1A63-75YA-P74
CKP1A63-75Y-P74
CKP1A63-75Y-P74-85G-X404
CKP1A63-B5052-50Y
CKP1A63-S0971-50
CKP1A63-S0971-75
CKP1AM63-200Y
CKPA80-150Y
CKQ40-25-DCH244DH
CKQ40-25-DCH245DH
CKQ40-25-DCH248DH
CKQ40-25-DCH249DH
CKQ40-P6136-25
CKQ40-P6138-25
CKQ40-P6140-25
CKQ40-P6142-25
CKQ40-P9616-25
CKQ40-W0377-25
CKQ40-W0378-25
CKQ40-W3950-25
CKQ40-W3951-25
CKQ50-15-DCJ9682J
CKQ50-DCG2437GA15
CKQ50-DCG2438GA15
CKQ50-DCG5907GL12
CKQ50-DCG5918GCA15
CKQ50-DCG7225G-16
CKQ50-DCG7226G-16
CKQ50-DCG5918GCA15
CKQ50-P5743-30
CKQ50-P7118-30
CKQ50-W3247-15
CKQ50-W3247A15
CKQ50-W3247B15
CKQ50-W8040A15
CKQ50-W8041A15
CKQGDB50-199RALS
CKQN50-25-155WA
CKQN50-25-158WA
CKQSC50-125RC
CKQSF50-125RDS
CHDKGB80150XB11
CHDMB20-Z0860
CHDMB20-200
CHDMB20-25
CHDMB20-40
CHDMB20-75
CHDMB20Z0860155
CHDMB25-50
CHDMB25-75
CHDMB32-100
CHDMB32-80
CHDMB40-250
CHDMB40K
CHDMC20-75
CHDMC32-80
CHDMC40-25
CHDMF20-40
CHDMF25-40
CHDMF32-350
CHDMF32-50http://www.chem17.com/st347484/list_1534753.html
CHDMF32K
CHDMG20-205
CHDMG32-75
CHDML20-400
CHDML25-200
CHDQB100-100
CHDQB100-100D
CHDQB100-25D
CHDQB100-50D
CHDQB100-75D
CHDQB100R184910
CHDQB20-0128624

上海維特銳實業發展有限公司現貨供應日本SMC系列產品，如需詳細了解請點擊：SMC全系列